On a PowrBeast 9700 the drive parts are on Main Assembly I and the Hydraulic System page: the 0537486 gas engine belt, the 537245 belt tensioner and the 449-195A and 449-984 pulleys. Controls such as the PCB and pressure control knob are on Main Assembly I. The wear parts are in Fluid Section II, led by the 138-153A repacking kit.
The 9700 diagram pages
The 9700 is Titan's largest PowrBeast, listed at 3.0 gpm with a Honda GX270 engine, and the site's unit for it is 0537007, PowrBeast 9700 (Honda). Its diagrams are split into the pages below. Open the one that matches the part you are chasing.
PowrBeast 9700 diagram pages
| Page | Parts it holds |
|---|---|
| Main Assembly I | Motor / Pump Assembly, gas engine belt, PCB, pressure control knob, fluid section assembly |
| Main Assembly II | Wheel, wheel spacer, pulley, solenoid assembly, hardware |
| Fluid Section II | Repacking kit, springs, valve seats and balls |
| Hydraulic System | Tank, filter, hoses, pulley, belt tensioner |
| Hydraulic Motor and Solenoid | Piston, seals, wear rings; solenoid coil and block |
| High Pressure Filter and Bleed Valve | Manifold filters, filter service kit; bleed valve housing, stem and seal |
| Cart and Accessories | Frame, handle; hoses, guns, tip parts, lube |
The full set of PowrBeast pages is on the PowrBeast parts page.
Drive and belt parts
The 9700 is gas-engine driven. Its Main Assembly I page lists 0537486, Belt, Gas Engine, and the 0537212A motor / pump assembly. The Hydraulic System page lists the 537245 belt tensioner assembly, which Titan's diagrams show only on the 9700 and not on the 4700 or 7700. The pulleys are 449-195A on the Hydraulic System page and 449-984 on Main Assembly II.
If the belt is the suspect part, check the manual for how to inspect and tension it. We do not give a belt life or tension procedure here because neither is something we can verify.
Controls
The controls on Main Assembly I are the 0537222A PCB board assembly, the 0537305B pressure control knob and its 0537554 knob adapter. The 2301766 control lamp appears on the Main Assembly pages for the other PowrBeast models too, so check the callout on the 9700 page.
Fluid section wear parts
The 9700 uses fluid section 0537256, the same as the 7700, according to Titan's fluid section page. The wear parts on Fluid Section II are:
- 138-153A repacking kit, with packing springs 142-004 and 142-003.
- 236-012 outlet valve seat and 0509710 outlet valve ball.
- 0509707 foot valve ball.
- 236-050 outlet valve assembly and 451-133A foot valve assembly.
- 451-131A piston rod, 144-832 pump cylinder and the 0537908 major service kit.
The piston rod must stay smooth; a scored rod destroys new packings, so inspect it before you repack. On the 9700 diagram the piston rod is 451-131A, while the 7700 diagram lists 451-131, so use the 9700 page for a 9700.
Filters and bleed valve
The high pressure filter page lists the 930-050 filter service kit, the 0537454A filter body and the manifold filters 930-005, 930-006 and 930-007. Clean filters after every job, since a partly blocked filter causes pressure loss and pulsing. The bleed valve page lists 944-009 valve housing, the 944-011 stem, 0294499 seal and 9841502 outlet valve ball, and the filter page also lists a 944-030A bleed valve assembly.
Ordering tips
Open the 9700 page
The 4700 and 7700 have separate fluid section and drive parts. Start from the 9700 pages above.
Match the callout
Find the numbered callout, then add that part number.
Check the manual for procedures
Belt tension and pressure relief steps are on our manuals page.
Call if unsure
Phone (713) 931-0006 with the model and serial number.
9700 parts from this guide:
The Short Version
Drive parts are the belt, tensioner and pulleys; controls are the PCB and pressure control knob; wear parts are in Fluid Section II. Use the 9700 pages, not the 4700 or 7700 ones, and call (713) 931-0006 when a callout is unclear.
Not sure which 9700 part you need?
Call (713) 931-0006 with your PowrBeast model and serial number and our parts team will confirm the part before you order.
(713) 931-0006Order by Parts Diagram